This thread started some discussion regarding the original color of the headlamp actuators.
Jon said his were Ford Blue on his 73, while I've only ever encountered either Zinc-Dichromate (yellow-gold) plating. I've owned a 73 (too rusted to tell), a 74, 75, 76, 77 , 77 and 79.
My cars were all high-mileage and pretty rusty, but tear-downs and close inspections always revealed remaining plating.
For those so motivated, can you inspect yours and determine if they are painted blue, black, or plated? Look for overspray on hoses to indicate someone painted them.
Note: 70-73s have ONE actuator in the center below the grille and 74-79s have two, one at each corner.
Authenticity manual writers need to know.
70-79 LCs: What color is your headlamp actuator?
Moderator: Dan Szwarc
- Dan Szwarc
- Site Admin
- Posts: 29890
- Joined: Fri Jun 16, 2000 1:01 am
- Contact:
70-79 LCs: What color is your headlamp actuator?
The below links are mostly dead.
Dan Szwarc: 1966 Convertible
Shop Manual or MPCs available
Signature rules.
Help the forum for 2024.
Dan Szwarc: 1966 Convertible
Shop Manual or MPCs available
Signature rules.
Help the forum for 2024.
-
- Frequent Contributor
- Posts: 217
- Joined: Sat Sep 06, 2014 5:32 pm
- Location: Australia
- Contact:
Re: 70-79 LCs: What color is your headlamp actuator?
the one's on my 79 are yellow/gold
- Dan Szwarc
- Site Admin
- Posts: 29890
- Joined: Fri Jun 16, 2000 1:01 am
- Contact:
Re: 70-79 LCs: What color is your headlamp actuator?
Poll added.
The below links are mostly dead.
Dan Szwarc: 1966 Convertible
Shop Manual or MPCs available
Signature rules.
Help the forum for 2024.
Dan Szwarc: 1966 Convertible
Shop Manual or MPCs available
Signature rules.
Help the forum for 2024.
- sauceman
- Addicted to Lincolns
- Posts: 1382
- Joined: Thu Sep 17, 2009 5:33 pm
- Location: Napanee, Ontario, Canada
- Contact:
Re: 70-79 LCs: What color is your headlamp actuator?
So what category would these fall under?
cheers
cheers
Good judgement comes from experience, and often experience comes from bad judgement.
Yugoslavia '94' , Israel/Syria '99 , Bosnia '02 , Afghanistan '08-'09
My 1977 Town Car build
Yugoslavia '94' , Israel/Syria '99 , Bosnia '02 , Afghanistan '08-'09
My 1977 Town Car build
- Dan Szwarc
- Site Admin
- Posts: 29890
- Joined: Fri Jun 16, 2000 1:01 am
- Contact:
Re: 70-79 LCs: What color is your headlamp actuator?
That's typical corrosion of Zn-Di.
For the record, next to cadmium plating, Zn-Di is one of the most corrosion resistant platings there is.
Here's a pic from a turn signal housing for my 70 Mercury: See the grey corrosion? That's sacrificial. Eventually, it turns to hard rust, like the rest, and like yours.
Remember, I'm an automotive engineer. I know materials, why they're chosen, etc.
For the record, next to cadmium plating, Zn-Di is one of the most corrosion resistant platings there is.
Here's a pic from a turn signal housing for my 70 Mercury: See the grey corrosion? That's sacrificial. Eventually, it turns to hard rust, like the rest, and like yours.
Remember, I'm an automotive engineer. I know materials, why they're chosen, etc.
The below links are mostly dead.
Dan Szwarc: 1966 Convertible
Shop Manual or MPCs available
Signature rules.
Help the forum for 2024.
Dan Szwarc: 1966 Convertible
Shop Manual or MPCs available
Signature rules.
Help the forum for 2024.
- Dan Szwarc
- Site Admin
- Posts: 29890
- Joined: Fri Jun 16, 2000 1:01 am
- Contact:
Re: 70-79 LCs: What color is your headlamp actuator?
I am not getting a lot of feedback from our membership, but I have found some supporting evidence for the Zinc-dichromate color that I claim is correct for all years: Some NOS actuators from Craigslist.
Pictures from the listing attached.
Pictures from the listing attached.
- Attachments
-
- 00s0s_aw74XO3aqdq_600x450.jpg (22.4 KiB) Viewed 1280 times
-
- 00202_jLknzCzMJMM_600x450.jpg (21.66 KiB) Viewed 1280 times
The below links are mostly dead.
Dan Szwarc: 1966 Convertible
Shop Manual or MPCs available
Signature rules.
Help the forum for 2024.
Dan Szwarc: 1966 Convertible
Shop Manual or MPCs available
Signature rules.
Help the forum for 2024.
-
- Addicted to Lincolns
- Posts: 1486
- Joined: Wed Dec 24, 2003 1:01 am
- Location: Long Island, NY
- Contact:
Re: 70-79 LCs: What color is your headlamp actuator?
Seeing these pictures, I will have to check the top side of my actuator in the Spring. I know I only touched up the bottom and for sure they would not be two tone. New actuators as shown further down in the thread may be different from those installed on the car as is typical with most Dealer replacement parts like valve covers, oil pans, etc.sauceman wrote:So what category would these fall under?
cheers
(Pic missing)
1973 Lincoln Continental Coupe
1958 Cadillac Sedan De Ville
1981 Corvette
2004 Mustang GT
1973 Lincoln Continental Coupe
1958 Cadillac Sedan De Ville
1981 Corvette
2004 Mustang GT
- LCont72
- Dedicated Enthusiast
- Posts: 520
- Joined: Wed Apr 24, 2013 1:07 pm
- Location: La Mesa, California
- Contact:
Re: 70-79 LCs: What color is your headlamp actuator?
My 1972 Lincoln, which was built late in the model year (June 20, 1972), has a zinc dichromate finish on the headlamp vacuum actuator.
Who is online
Users browsing this forum: No registered users and 0 guests